Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 99V028000: Fuel Pump/Sender Assembly Wire Harness
- Recall - Fused Jumper Harness Installation
- Recall 97V204000: Drivetrain Structural Failure
- Recall - Accessory Power Circuit Relay Installation
- Recall 98E010000: Brake Rotor Cracking
- Recall 99V029000: Accessory Electrical Short Circuit
- Recall - Transfer Case Update
- Customer Interest
- Air Conditioning - Musty/Mildew Type Odors
- Power Steering System - Noisy
- Engine - Carbon Knock On Acceleration
- Cooling System - Coolant Loss
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- A/C - Insufficient Cooling/ Compressor Failure
- Blower Motor - Chirp/Squeak
- Blower Motor - Chirping/Squeaking
- Cooling System - Thump Noise/Gauge Fluctuation
- Steering - Rapping or Clanging Noise
- Door Lock Cylinder - Loose in Replacement Door
- Sliding Door Weatherstrip - Worn or Damaged
- Headliner - Objectionable Odor
- Rear Axle - Whine/Howl At Light Throttle
- Exhaust System - Sulfur/Rotten Egg Smell
- PCM - MIL ON/Code 124 Set
- Engine - Lean Driveability Symptoms
- Accessory Drive Belt - Squeal or Hoot Noise
- Ignition Switch - Harness Connector Non-Mating
- Heated Backlite - Inoperative
- Electronic Fuel Gauge - Erratic Readings
- Left Rear Tire - Rubs On Wheelhouse Inner Panel
- A Pillar/Door - Wind Noise
- Rocker Panel - Front/Rear Rust Perforation
- Differential - Chatter On Turns
- Front Drive Axle - Fluid Leak From Vent
- Sliding Door Latch - Damaged or Misadjusted
- Instrument Panel/Windows - Rattle/Buzz
- Rear View Mirror - Detaches From Windshield
- Exhaust System - Buzzing/Rattling Noise
- Engine - Noise/Vibration/No Crank/No A/T Engagement
- Speedometer/Odometer - (Programmable) Pointer Waiver
- A/T - Inadvertent Shift Interlock Disabling
- Steering Wheel - Clicking Noise Heard When Turning
- Transfer Case - Leaks From Vent Tube
- Front Door Glass - Binds During Downward Travel
- A/T - Torque Converter Slip/DTC 628/P0741 Set
- Chemicals,Additives
- Factory Modifications
- Labor/Parts Updates
- Superceded Bulletins
- 9566 - 05/08/95
- `A' Pillar/Door - Wind Noise
- Headliner - Objectionable Odors
- A/C - Musty and Mildew Type Odors
- A/C - Identification Of Non Approved Refrigerants
- Air Conditioning - Musty Odors
- A/C - Approved Flushing Procedures
- Blower Motor - Chirping/Squeaking At Low Speeds
- Blower Motor - Chirping or Squeaking Noise
- Blower Motor - Chirping/Squeaking Noise
- Blower Motor - Chirp or Squeak
- Blower Motor - Chirp/Squeak at Low Speeds
- Blower Motor - Chirp or Squeak at Low Speeds
- Frame - Rivet Replacement With Bolts, Service Tip
- Power Steering - Rapping or Clanging Sound
- Power Steering - 'Rapping' or 'Clanging' Noise
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Repair
- Wire Harness - Terminal Repair Kit/Splice Procedure
- Wire Harness - New Terminal Repair Kit
- Brakes - Service Tips
- Brakes - Special Lubricant Requirements
- Brakes - Roughness/Vibration
- Brake Rotor - Hub Mounted Machining Equipment
- Brakes - Rotor/Drum Sanding Elimination
- Rear Axle - Whine or Howl During Light Throttle
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Brake Shift Interlock - Inadvertent Disabling
- Fuel Economy - Customer Expectations Vs. Vehicle Usage
- Fuel - Volatility Related Concerns
- Fuel Economy - Expectations Versus Usage
- Speaker - Whining/Buzzing Noise
- Speakers - Whining/Buzzing Noise
- Fuel Pump - Buzz/Whine Through Radio Speakers
- Fuel Pump - Whine/Buzz Noise Heard In Speakers
- Radio - Whine/Buzz
- Fuel - Volatility Related Driveability Information
- PCM - MIL ON/Flashing/Continuous Code 124
- Exhaust System - Buzzing/Rattling Noises
- Exhaust System - Rattling/Buzzing Noise
- Exhaust System - Buzz/Rattle Noise
- Heater Core - Repeated Failure
- A/T - Fluid Application Charts
- A/C - Refrigerant Filtering Tips
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Air Conditioning - Lack of Cooling/Compressor Failure
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- Propylene Glycol Coolant - Recommendations
- Recycled Engine Coolant - Service Tip
- A/T - Transmission Fluid Usage Charts
- Automatic Transmission - Fluid Usage Charts
- A/C - Filter Kit Installation After Replacing Compressor
- A/C Compressor Replacement - Refrigerant Filtering
- Air Conditioning - Filtering Refrigerant
- A/C - R134A Tracer Dye Factory Installed
- A/C - Non Approved Refrigerants
- A/C - Approved/Alternate Refrigerants
- A/C - Identification of Non-Approved Refrigerants
- A/C - Identifying Non-Approved Refrigerants
- A/C - Lack of Cooling/Compressor Failure
- Vehicle - Towing Guidelines
- All Technical Service Bulletins
- Vehicle - Towing Behind RVs Guidelines
- A/C System - Service TSB List
- Air Conditioning - Musty/Mildew Type Odors
- A/C - Filtering Refrigerant After Compressor Replacement
- Power Steering System - Noisy
- Engine - Revised Torque Procedures and Specifications
- Engine - Carbon Knock On Acceleration
- Cooling System - Coolant Loss
- Electrical - New Terminal Grease Released For Service
- Throttle Position Sensor - Function and Diagnostic Tips
- Recall 99V028000: Fuel Pump/Sender Assembly Wire Harness
- Recall - Fused Jumper Harness Installation
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Brake and Rotor - Service Tips
- Platinum Spark Plugs - Identification/Location
- A/C - Insufficient Cooling/ Compressor Failure
- Blower Motor - Chirp/Squeak
- Blower Motor - Chirping/Squeaking
- A/C Evaporator Core - On Vehicle Leak Test Requirement
- Air Conditioning - Approved Flushing Procedures
- Cooling System - Thump Noise/Gauge Fluctuation
- Cooling System - New System Diagnostics
- Radiator - New Manufacturing Process
- Rear Main Oil Seal Replacement - Service Tip
- Steering - Rapping or Clanging Noise
- Lug Nuts - Proper Installation/Torqueing Procedure
- Frame - Rivet Replacement with Bolts Service Tip
- Door Lock Cylinder - Loose in Replacement Door
- Sliding Door Weatherstrip - Worn or Damaged
- Headliner - Objectionable Odor
- Recall 97V204000: Drivetrain Structural Failure
- Rear Axle - Whine/Howl At Light Throttle
- Torque Converter - Cleaning and Replacement Guidelines
- A/T - Cooler Flushing Service Tips
- A/T Torque Converter - Leak Test Procedure
- Hydraulic Clutch - Bleeding Procedure Service Tips
- Universal Joint - Greasable Design Availability
- Fuel Injectors - Non Warranty Reimbursement Testing
- Exhaust System - Sulfur/Rotten Egg Smell
- PCM - MIL ON/Code 124 Set
- Heated Exhaust Gas Oxygen Sensor - Application Chart
- EGO Sensors - Silicone Contamination
- Mass Air Flow Sensor - Assembly Replacement
- Engine - Lean Driveability Symptoms
- Accessory Drive Belt - Squeal or Hoot Noise
- Campaign - RABS Module Inspection/Replacement
- Starter Solenoids and Drives - Obsolete Parts Return
- Ignition Switch - Harness Connector Non-Mating
- Recall - Accessory Power Circuit Relay Installation
- Ignition Control Module - Connector Update
- Connector, DIS Ignition Revised
- Accelerator Cable - Service Procedures/Tips
- Heated Backlite - Inoperative
- Air Bag Modules - Discolored/Marred Covers
- Brake Rotor - Machining Equipment/Warranty Information
- Brakes - Elimination Of Sanding Rotors And Drums
- Hub-Mount Brake Rotor Machining Equipment
- Recall 98E010000: Brake Rotor Cracking
- Electronic Fuel Gauge - Erratic Readings
- Temperature Gauge - Reads Low/Erratic
- Left Rear Tire - Rubs On Wheelhouse Inner Panel
- A Pillar/Door - Wind Noise
- Sheet Molding Composite - Body Repair
- Rocker Panel - Front/Rear Rust Perforation
- Recall 99V029000: Accessory Electrical Short Circuit
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- Differential - Chatter On Turns
- Front Drive Axle - Fluid Leak From Vent
- Sliding Door Latch - Damaged or Misadjusted
- Windshield - Material Usage Procedure
- Windshield/Interior Glass - Fog/Film
- Glass - Iridescence or Mottling In Tempered Glass
- Instrument Panel/Windows - Rattle/Buzz
- Rear View Mirror - Detaches From Windshield
- Rear View Mirror - Reattachment
- Bumper Cover - Repair Materials Update
- Paint - Procedure/Products For Plastic Service Parts
- Motor Oil - Viscosity Grade Recommendation
- Recycled Engine Coolant - Service Tips
- Engine Coolant - Propylene Glycol Recommendations
- Exhaust System - Buzzing/Rattling Noise
- A/T - A4LD/4R44E/5R55E New Center Support
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - In Line Fluid Filter Kit
- A/T - Transmission Flush and Fill Tool Available
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - A4LD Malfunction Indicator Lamp Flashing, Code 24
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Engine - Noise/Vibration/No Crank/No A/T Engagement
- A/T - Mercon V ATF Usage
- Speedometer - Recalibration Tips
- Speedometer/Odometer - (Programmable) Pointer Waiver
- Engine - New Gasket Sealer
- Wire Harness - Terminal Repair Kit
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Paint - Codes/Cross References
- Paint - Codes and Supplier Stock Numbers
- Paint - Preparation Procedure And MSDS Information
- Paint - Iron Particle Removal
- A/T - Inadvertent Shift Interlock Disabling
- Electrical Diode - Identification and Replacement
- Steering Wheel - Clicking Noise Heard When Turning
- A/T - A4LD Servo Cover Heat Shield
- A/C - Release of R134a Fluorescent Dye
- A/C - Identification of Non Approved Refrigerants
- Recall - Transfer Case Update
- Transfer Case - Leaks From Vent Tube
- Air Conditioning - O Ring Removal Service Tip
- A/C O Ring - Availability and Applications
- A/C - New O Ring Applications
- Front Door Glass - Binds During Downward Travel
- Brakes - New Silicone Compound/Grease
- Brake Service - Service Tips
- Brakes - Vibration/Inspection Service Tips
- A/C - Oil Visible At Spring Lock Couplers
- Fuel - California Reformulated Gasoline
- Fuel - Volatility Related Driveability Concerns
- Suspension/Steering - Front Alignment Settings
- A/C - Adding Refrigerant Oil Service Tip
- A/C - Refrigerant Oil Refill Capacity
- A/C Compressor - Service Tips
- Seat Leather - Cleaning Procedure Tips
- M/T - Mercon(R) V ATF Usage Information
- A/T - Torque Converter Slip/DTC 628/P0741 Set